| 290 | 2 | 56 |
| 下载次数 | 被引频次 | 阅读次数 |
离子聚合物金属复合材料(IPMC)是一种新型的电驱动软材料，具有质量轻、驱动电压低的优点，但也存在输出力较小、驱动时间短的缺点，限制了其应用前景。提出了一种在基膜内掺杂硅酸乙酯-氧化石墨烯(TEOS-GO)以提高保水性和驱动能力的银基IPMC,通过对纯Nafion IPMC与TEOS-GO/Nafion IPMC致动器的含水量、尖端位移、输出力和稳定性等参数的测试，证实优化后IPMC的驱动性能有明显的提升。实验结果表明，掺杂质量分数1.5%TEOS-GO的IPMC在3 V直流电压下，尖端位移达到16.579 mm,相当于纯Nafion IPMC的3.37倍；输出力最高达到0.439 gf(1 gf=9.8 mN),是纯Nafion IPMC的5倍。这种改进方式弥补了IPMC用于致动器的缺点，为今后的发展开拓了前景。
Abstract：Ionic polymer metal composite(IPMC) is a new kind of electric driven soft material, and has advantages such as light weight and low driving voltage. However, it also has limitations such as small output force and short driving time, which restrict its application prospects. A silver-based IPMC with ethyl silicate-graphene oxide(TEOS-GO) doped in the base film to improve water retention and driving capability was proposed. By measuring water content, tip displacement, output force and stability of pure Nafion IPMC and TEOS-GO/Nafion IPMC soft actuators, it is confirmed that the driving performance of the optimized IPMC has been significantly improved. The experimental results show that the tip displacement of IPMC doped with 1.5% mass fraction TEOS-GO reaches 16.579 mm at 3 V DC voltage, which is 3.37 times that of pure Nafion IPMC. The maximum output force reaches up to 0.439 gf(1gf=9.8 mN), which is 5 times that of pure Nafion IPMC. The optimization approach addresses the drawbacks of IPMC for actuators and opens up prospects for future development.
[1] NAKSHATHARAN S S,MARTINEZ J G,PUNNING A,et al.Soft parallel manipulator fabricated by additive manufacturing [J].Sensors and Actuators:B,2020,305:127355.
[2] JO C,PUGAL D,OH I K.Recent advances in ionic polymer-metal composite actuators and their modeling and applications [J].Progress in Polymer Science,2013,38(7):1037-1066.
[3] ARSHAD M,DU H L,JAVED M S,et al.Fabrication,structure,and frequency-dependent electrical and dielectric properties of Sr-doped BaTiO3 ceramics [J].Ceramics International,2020,46(2):2238-2246.
[4] YILMAZ O C,SEN I,GURSES B O,et al.The effect of gold electrode thicknesses on electromechanical performance of Nafion-based ionic polymer metal composite actuators [J].Composites:B,2019,165:747-753.
[5] DAI J,ZHANG M M,ZHOU F Y,et al.Highly efficient tunable optical filter based on liquid crystal micro-ring resonator with large free spectral range [J].Frontiers of Optoelectronics,2015,9:112-120.
[6] MONTAZAMI R,WANG D,HEFLIN J.Influence of conductive network composite structure on the electromechanical performance of ionic electroactive polymer actuators [J].International Journal of Smart and Nano Materials,2012,3(3):204-213.
[7] KIM C,KIM S J,YANG H,et al.An auto-focus lens actuator using ionic polymer metal composites:design,fabrication and control [J].International Journal of Precision Enginee-ring & Manufacturing,2012,13(10):1883-1887.
[8] LEE B K,PARK S J,KIM D S.Fabrication of ionic polymer actuator with graphene nanocomposite electrodes and its characterization [J].Current Applied Physics,2013,13(7):1520-1524.
[9] GUO D J,WANG L,WANG X J,et al.PEDOT coating enhanced electromechanical performances and prolonged stable working time of IPMC actuator [J].Sensors and Actuators:B,2020,305:127488.
[10] XUE Z G,TANG Y J,DUAN X L,et al.Ionic polymer-metal composite actuators obtained from sulfonated poly(ether ether sulfone) ion-exchange membranes [J].Compo-sites:A,2016,81:13-21.
[11] MA Y,DI H H,YU Z X,et al.Fabrication of silica-decorated graphene oxide nanohybrids and the properties of composite epoxy coatings research [J].Applied Surface Science,2016,360:936-945.
[12] YESASWI C S,SREEKANTH P S R.Characterisation of silver-coated teflon fabric-reinforced Nafion ionic polymer metal composite with carbon nanotubes and graphene nano-particles [J].Iranian Polymer Journal,2022,31(4):485-502.
[13] ZHANG M L,WANG M,ZHANG X J,et al.Fabrication of a multilayered SGO/macroporous Nafion-based IPMC with enhanced actuation performance [J].Sensors and Actuators:B,2022,356:131319.
[14] 杨伟.氧化石墨烯、石墨烯的制备及其功能复合膜研究 [D].天津：天津大学，2011.YANG W.Study on preparation of graphene oxide,graphene and them-based composite membranes [D].Tianjin:Tianjin University,2011.
[15] ZHU Z Y,JIANG J L,WANG X D,et al.Improving the hydrophilic and antifouling properties of polyvinylidene fluoride membrane by incorporation of novel nanohybrid GO@SiO2 particles [J].Chemical Engineering Journal,2017,314:266-276.
[16] JIANG T W,KUILA T,KIM N H,et al.Enhanced mechanical properties of silanized silica nanoparticle attached graphene oxide/epoxy composites [J].Composites Science and Technology,2013,79(5):115-125.
[17] ZHAO X,ZHANG Q H,CHEN D J,et al.Enhanced mechanical properties of graphene-based poly(vinyl alcohol) composites [J].Macromolecules,2010,43(5):2357-2363.
[18] WANG L Z,TOMURA S,OHASHI F,et al.Synthesis of single silica nanotues in the presence of citric acid [J].Journal of Materials Chemistry,2001,11(5):1465-1468.
[19] NING H L,YANG Z Y,WANG D C,et al.Graphene-based semi-coke porous carbon with N-rich hierarchical sandwich-like structure for efficient separation of CO2/N2 [J] .Microporous Mesoporous Materials,2021,311:110700.
[20] KANG L,ZHAO L,YAO S,et al.A new architecture of super-hydrophilic β-SiAlON/graphene oxide ceramic membrane for enhanced anti-fouling and separation of water/oil emulsion [J].Ceramics International,2019,45(13):16717-16721.
[21] BISWAL D K,NAYAK B.Analysis of time dependent bending response of Ag-IPMC Actuator [J].Procedia Enginee-ring,2016,144:600-606.
[22] YESASWI C S,SAHU S K,SREEKANTH P S R.Experimental investigation of electro-mechanical behavior of silver-coated teflon fabric-reinforced Nafion ionic polymer metal composite with carbon nanotubes and graphene nanoparticles [J].Polymers,2022,14(24):5497.
[23] CHANG W,LIAN H Q,HU Y O,et al.Enhanced electromechanical performance of graphene oxide-Nafion nanocomposite actuator [C] // Proceedings of International Symposium on Material,Energy and Environment Engineering.Changsha,China,2015:9659-9663.
基本信息:
DOI：10.13250/j.cnki.wndz.24030303
中图分类号:TB333
引用信息:
[1]李星震,李廷鱼,郭丽芳,等.TEOS-GO掺杂的银基离子聚合物金属复合材料的制备及其致动性能[J].微纳电子技术,2024,61(03):81-88.DOI:10.13250/j.cnki.wndz.24030303.
基金信息:
山西省自然科学研究面上项目(20210302123157); 山西省回国留学人员科研资助项目(2023-052)
2024-03-07
2024-03-07
2024-03-07